Product ID:ABLEBOND 36-2
MSDS Date:01/14/1988
FSC:8040
NIIN:01-101-5662
MSDS Number: BHNZW

ABLESTIK LABORATORIES

833 WEST 182 STREET
GARDENA, CA 90248

Emergency Phone: 213-532-9341

Info Phone: 213-532-9341

Cage: 9V874

ABLESTIK LABS SUB OF NATIONAL STARCH AND CHEMICAL

COMPTON, CA 90221 US

Telephone: 310-764-4600

Cage: 21109

SILVER (SARA III)

CAS: 7440-22-4

RTECS: VW3500000

OSHA PEL 0.01 MG/M3

ACGIH TLV: 0.1 MG/M3; 9192

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

VINYL CYCLOHEXENE DIOXIDE

CAS: 106-87-6

RTECS: RN8640000

OSHA PEL S, 10 PPM

ACGIH TLV: S, 10 PPM ;A2; 9192

RESORCINOL DIGLYCIDYL ETHER (RDE).LD50 ORAL RAT 1.57

CAS: 101-90-6

RTECS: VH1050000

OSHA PEL N/K

ACGIH TLV: N/K

4,4'-ISOPROPYLIDENEDIPHENOL (SARA III)

CAS: 80-05-7

RTECS: SL6300000

LD50 LC50 Mixture:N/K
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE DERMAT,SENSIT,SKIN
CANCER.RESORCINOL DIGLYCIDYL ETHER:REPEAT/PROLONGED SKIN CONTACT
WILL CAUSE SEVERE INJURY.
Explanation of Carcinogenicity:VINYL CYCLOHEXENE DIOXIDE:ACGIH A2=SUSP
HUMAN CARC (1989).NO ADEQUATE DATE TO ALLOW AN EVALUATION OF CARC
IN (SEE SUPP)
Effects of Overexposure:EYES:EXTREME IRRIT.SKIN:MAY CAUSE
DERMAT,SENSIT,RASH.ABSORB-MAY CAUSE NAUSEA,VOMIT,OTHER ILLNESS
SIGNS.VINYLCYCLOHEXENE DIOXIDE-SWELL,REDNESS LIKE BURN.RESORCINOL
DIGLYCIDYL ETHER-SEVERE IRRIT.REPEAT/ PROLONG CONTACT CAUSE SEVERE
INJURY.SYMP LIKE POISON IVY/SUMAC.INGEST:SLIGHT ORAL
TOXICITY.INHAL:HARMFUL TO RESP SYS.
Medical Cond Aggravated by Exposure:N/K

First Aid:EYES:FLUSH WITH WATER FOR AT LEAST 15 MINUTES.GET MEDICAL
ATTENTION.SKIN:WASH IMMEDIATELY WITH SOAP & WATER.IF IRRITATION
PERSISTS,GET MEDICAL ATTENTION IMMEDIATELY.INGESTION:GET MEDICAL
ATTENTION IMM EDIATELY AND SHOW INSERT CARD.INHALATION:REMOVE TO
FRESH AIR IMMEDIATELY.

Flash Point Method:COC
Flash Point:110C,213.8F
Extinguishing Media:CARBON DIOXIDE,DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE KNOWN.HAZARDOUS DECOMPOSITION
PRODUCTS (INCLUDING COMBUSTION PRODUCTS):CARBON MONOXIDE &/OR
CARBON DIOXIDE.

Spill Release Procedures:WIPE UP WITH SOLVENT SATURATED TOWELING AND
COLLECT IN AN APPROPRIATE CONTAINER FOR DISPOSAL.
Neutralizing Agent:N/K

Handling and Storage Precautions:STORE REGRIGERATED AT ALL TIMES.VENT
CURING OVEN TO OUTDOORS.SKIN BARRIER CREAM EFFECTIVELY PROTECTS
MOST PERSONNEL ROUTINELY HANDLING THESE INGRED.
Other Precautions:DURING MAINTENANCE OF CONTAMINATED EQUIPMENT AVOID
CONTACT WITH SKIN,EYES,CLOTHING.GOOD HOUSEKEEPING IS REQUIRED.AVOID
INHALATION OF VAPORS.

Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW TLV .VENT CURING OVEN TO OUTDOORS.
Protective Gloves:RUBBER
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:PROTECTIVE EQUIPMENT TO COVER EXPOSED AREAS.
Work Hygienic Practices:GOOD INDUSTRIAL HYGIENE PRACTICES SHOULD BE
FOLLOWED WHEN HANDLING THIS PRODUCT.
Supplemental Safety and Health
VOLATILE BY WT:<1%.EXPLAN OF CARCIN:HUMANS;LIMITED EVIDENCE FOR CARC IN
ANIMALS (IARC,1987).RESORCINOL DIGLYCIDYL ETHER:NO ADEQUATE DATE TO
ALLOW AN EVALUATION OF CARC IN HUMANS;SUFFICIENT EVIDENCE FO R CARC
IN ANIMALS (IARC,1987).

Boiling Pt:B.P. Text:440.6F,227C
Decomp Temp:Decomp Text:N/K
Vapor Pres:0.1 MMHG
Vapor Density:N/K
Spec Gravity:3.2 (WATER=1)
Evaporation Rate & Reference:N/K
Solubility in Water:NIL
Appearance and Odor:SILVER PASTE;PLEASANT ODOR.

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT PRIOR TO CURE.
Hazardous Decomposition Products:(INCLUDING COMBUSTION PRODUCTS):CARBON
MONOXIDE AND/OR CARBON DIOXIDE.
Conditions to Avoid Polymerization:EXCESSIVE HEAT.IF NOT USED FOR THIN
BOND LINE APPLICATN,VIOLENT CHEM RXN CAN RESULT.USE W/ CAUTION UPON
CURING.

Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .DISPOSE IN APPROVED CHEMICAL
DISPOSAL AREA OR IN A MANNER WHICH COMPLIES WITH ABOVE REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.